GENERAL SERVICING

Complete schedule of LUBRICATION SERVICE offered by ICON AUTO Garage, recommended every 5000 kms or at least every 6 months:

- Drain old oil, flush engine & refill with top quality oil
- Renew oil filter
- Clean out engine breathers
- Top-up gearbox, axle, power steering & steering box
- Top-up brake fluids & washer bottles
- Grease up all accessible suspension joints
- Lubricate door & tailgate/boot hinges & locks etc...
- Clean, lubricate & adjust throttle linkages
- Check & report on engine & transmission leaks
- Check & report on brake, steering & suspension leaks
- Check cooling system & pressure test for external leaks
- Electronically test brake fluid (for boiling point) moisture content

back to top

Complete schedule of UNDER BONNET SERVICE offered by ICON AUTO Garage, recommended every 10,000 kms or at least every 12 months:

- Change Engine oil and filter - Valve clearance, check and adjust (except hydraulic adjusters) - Air cleaner, paper element, check and renew if required

- Ignition System check (points, cap, rotor arm if applicable)
- Spark Plugs, renew
- Ignition Timing, check, renew if required
- Engine idle speed, measure and adjust CO if required
- Fuel System, check for leaks
- Drive Belts, check and adjust
- Cooling System, check for antifreeze strength and leaks, top up coolant
- Battery, check condition, top up if applicable, clean and grease terminals
- Carburetor, check security, top up damper if applicable
- Power Steering, check for leaks, top up if required
- Check Brake and Clutch fluid, top up if required
- Automatic Transmission, if fitted, check oil level, top up if required
- Screen Washers, top up reservoir
- Bonnet Release Catch and Hinges, check operation and lubricate

back to top

Complete schedule of UNDER THE VEHICLE SERVICE offered by ICON AUTO Garage, recommended every 10,000 kms or at least every 12 months:

- Remove Road Wheels, check front disc condition and pad wear
- Remove Drums if applicable, check lining condition and examine cylinders
- Check Handbrake travel, adjust if required
- Brake pipes and hoses, check for leaks and corrosion
- Exhaust System, check for security, leaks and corrosion
- Ball joints and transmission, check for wear
- Shock Absorbers, check for condition and operation
- Steering Gear, check for wear & gaiters for leaks
- CV joints (FWD) check for wear and gaiters for splits
- Clutch, adjust if required (if applicable)
- Tracking, check
- Gearbox, rear axle (if applicable), check oil level, top up if required
- Tyres, check and report condition, correct inflation, including spare

back to top

Complete schedule of INSIDE THE VEHICLE SERVICE offered by ICON AUTO Garage, recommended every 10,000 kms or at least every 12 months:

- Interior lights and instrument lights, hazard light switch check
- Windscreen and headlamp, washers and wipers, check
- Door hinges and locks, lubricate
- Heating and ventilation controls, check

Complete schedule of OUTSIDE THE VEHICLE SERVICE offered by ICON AUTO Garage, recommended every 10,000 kms or at least every 12 months:

- Lights, check operation
- Headlamps, check alignment
- Boot lid / tailgate hinges, lubricate
- Refit road wheels, tighten retaining nut to the correct torque

Complete schedule of ROAD TEST SERVICE offered by ICON AUTO Garage, recommended every 10,000 kms or at least every 12 months:

- Check operation of vehicle
- Check all instruments function properly
- Brake test